Monday 7 March 2011

Hops in WW II

You guessed it. We're still back in 1943 with Wallenstein Laboratories. I'll be hewing rock in this particular data mine for a while yet.

This time it's hops. One area where WW II differed totally from WW I.
"Hops

In Great Britain most of the beer — one might say almost all — is unpasteurized and therefore dependent on hop antiseptics for its freedom from acid-forming bacteria. The restriction in supplies of hops gave rise to fears that bacterial instability would appear and perhaps increase, and that the flavor of beers would be detrimentally affected. Possibly difficulties have been experienced in connection with filtration of the wort through the hop back in certain breweries. But matters have not proved so bad as have been feared. For instance, no complaints have been heard regarding filtration, while the change in beer flavor has been gradual, and like that arising from the reduction in gravities, has been noticed much less by the public than if it had occurred suddenly. Moreover, such changes are accepted as inevitable.

The reduction in hop supplies has been serious. In June, 1941, a 20 per cent cut was imposed in the gross amount available to the trade. The actual quantity which passed through the Hops Marketing Board (which controls hops and their distribution) was 75 per cent of the total brewers' nominations. These nominations would have been the same in 1941 as the consumption during the datum year, if as many standard barrels had been brewed as in that year. But in 1942 the nominations, themselves, had to be cut by 20 per cent, and then only 80 per cent of the nominations were available, i.e., 64 per cent of the prewar quantities. In the present year hop rates in practice are about 1 to 1.2 lb per standard barrel, i.e., about 0.3 per cent, whereas in normal times this would have been almost double.

Hops are obtainable only under license, and a brewer who runs short may apply to the Brewers' Society for permission to secure a further allowance from his nominated merchants. Brewers usually carry a stock of hops over from one season to the next, new hops rarely being used. By now all reserves of this kind have been used up and brewers are living from hand to mouth; in many cases they have to use the new season's hops as soon as these are delivered. Matters were not helped during the London blitz back in late 1940, when some 50,000 pockets of hops were burnt. It was also on this occasion that the historic building, Brewers'
Hall — the home of the Institute of Brewing — was completely destroyed.

On the whole bacterial contamination, although on the increase, has not become so prevalent as was expected and most beer is being racked into casks comparatively free from both bacterial and wild-yeast infection. Even where instability is on the increase the quick consumption of the beer largely removes the trouble. In the summer of 1942 instability due to bacteria was unusually serious for a time in some beers, as indicated by laboratory tests. But the warm weather conditions which favored the growth of bacteria also increased beer consumption, thereby preventing much beer from being returned to the brewers. Since that time, however, the trouble has largely disappeared. No doubt the main causes were to be sought in low hop rates and lack of labor for adequate cleansing and sterilizing of plant, casks, etc."
"Wallenstein Laboratories Communications, December 1943, Volume VI, number 19" pages 156 - 157.

When the government imposed restrictions on the brewing industry in 1917, the demand for hops dropped dramatically and there was a glut. They government had to buy the whole 1917 crop to prevent the industry being destroyed. 1917 hops were still showing up in brewing records years after the war. In WW II there wasn't the same sudden drop in beer output and the British growers weren't able to meet demand. Britain had, of course, been dependent on imported hops for nearly a century.

Brewers had always liked to mix hops from different seasons to even out any changes in flavour. Running out of stocks from previous years must have been a real headache. I can imagine that there musty have been some pretty dramatic fluctuations in beer flavour as they swapped from one year's crop to the next. I knew that in the early part of the blitz many London warehouses and the goods within them had been destroyed. I hadn't realised hops had been one of the commodities affected.

With beer in short supply and being consumed within a few days of being brewed, the antiseptic qualities of hops would have been less required. In the days of Stock Ales kept for months before sale, this would have been much more of a problem. But by 1939, the vast majority brewed was already running beer.

The hop rates quoted don't quite tally with the numbers I have, based on the quantity of hops used and the amount of beer brewed. Take a look:

Brewing materials (%age)
year
malt
unmalted corn
rice, maize, etc
sugar
total malt & adjuncts
hops per bulk barrel (lbs)
hops per standard barrel (lbs)
Hops per quarter (lbs)
barrels per qtr malt & adjuncts
1938
78.31%
0.12%
5.75%
15.82%
11,975,941
1.28
1.71
7.80
6.10
1939
78.35%
0.08%
5.82%
15.75%
12,615,962
1.25
1.67
7.61
6.11
1940
83.81%
0.07%
3.09%
13.03%
11,762,114
1.19
1.62
7.58
6.36
1941
86.90%
0.09%
1.95%
11.05%
12,644,709
1.00
1.43
6.68
6.68
1942
85.54%
0.41%
2.99%
11.06%
12,764,377
0.84
1.31
5.87
6.95
1943
79.34%
0.31%
9.55%
10.80%
12,966,670
0.87
1.39
6.00
6.90
1944
78.88%
1.06%
9.22%
10.83%
13,464,119
0.87
1.38
6.09
6.99
1945
75.63%
1.78%
9.65%
12.93%
13,797,059
0.86
1.36
5.96
6.96
1946
76.53%
1.06%
8.69%
13.73%
13,037,517
0.82
1.29
5.83
7.15
1947
80.37%
0.79%
5.22%
13.61%
11,762,748
0.81
1.37
6.22
7.68
1948
81.75%
0.60%
5.22%
12.42%
11,620,172
0.90
1.52
6.69
7.44
1949
82.94%
0.55%
4.61%
11.89%
10,956,343
0.98
1.61
7.15
7.32
1950
83.50%
0.52%
4.17%
11.81%
10,890,648
1.03
1.67
7.19
6.98
1951
83.27%
0.52%
4.06%
12.16%
11,147,566
1.03

6.91
6.69
1952
83.02%
0.46%
4.16%
12.35%
11,217,454
1.01

6.84
6.76
1953
82.78%
0.53%
3.89%
12.80%
10,975,250
1.02

6.91
6.78
Source:
my calculation from figures in 1955 Brewers'Almanack, page 62
Notes:
assumes a quarter = 336 lbs


It shows the hopping rate per standard barrel (36 gallons of beer with a gravity of 1055º) declined from 1.71 lbs in 1938 to 1.39 lbs in 1943, when the article was written. I make that about a 19% decrease, way short of the 50% suggested. Note how soon after the war, in 1950, the rate per standard barrel was back to its 1939 level.

7 comments:

Lars Marius Garshol said...

> Note how soon after the war, in 1950,
> the rate per standard barrel was back
> to its 1939 level.

Hmmm? To me it looks like the rate never got back to the 1939 level. 1.0 is substantially less than 1.2.

Ron Pattinson said...

Lars, you're looking at the hopping rate per bulk barrel, not standard barrel. By comparing the standard barrel figure it removes the effect of changes in gravity.

Craig said...

So any indication or evidence that beers produced after the imposed 1941 cut (and I assume through the end of the war) were less bitter? Was there an increase of mild production at this point?

Ron Pattinson said...

Craig, were beers less bitter? Good question. They were certainly hopped at a lower rate. Then again, they were using mostly fresh hops, whereas pre-war some would have been yearlings or even older.

I haven't got any figures on sales per style. I do know that breweries reduced their range of beers. For example, Barclay Perkins dropped their Best Bitter and a couple of their Milds.

Craig said...

So, I did a little educated guess work. Wednesday the 23rd's post, conveniently, had two charts comparing Whitbread beers of 1939 and 1943. Comparing the stouts (MS), pale ales and IPAs, I calculated a 26% loss in gravity and a 65% drop in hops lbs/brl for the stout a 20% loss of gravity and a 30% drop in hops lbs/brl for the PA and finally an 18% loss of gravity and a 28% drop in hops lbs/brl for the IPAs. Armed with that info I created a few period-esque recipe to test the hypothesis.

STOUT (MS)
For both years, the stout were made from pale, brown, and black malt with a little roasted barley and dark invert. Hopping was done at intervals of 90, 60, 30 and 10 minutes (using Cluster and East Kent Goldings) with the appropriate amount of hops, depending on the year. The BU:GU ratio for 1939 was 1.16 and for 1943, 1.08. Accounting for yearling plus hops in 1939 and fresh hops in 43, I'd say bitterness was about equal with a reduction of 7%. A drop of eight gravity points from 1051 to 1043, is significant, but there's are some bold flavors in the stout, so that may have convoluted things.

PALE ALE
The Pales were made from pale, crystal, and light invert. Again, hopping was done at intervals of 90, 60, 30 and 10 minutes (using Cluster and East Kent Goldings) with the appropriate amount of hops, depending on the year. The BU:GU ratio for 1939 was 1.67 and for 1943, 1.47. A 12% decrease within four years is pretty significant. Yearling hops may have played role in muting the bitterness, but even with the reduction the 20% drop in gravity may have counteracted that. It seems that there would still be some malt sweetness with a gravity of 1038 as well as a good bit of bitterness, but there may have been a noticeable decline in bitterness as well.

IPA
The IPA grist was identical to the pales, using pale, crystal, and light invert. Again, hopping was done at intervals of 90, 60, 30 and 10 minutes (using Cluster and East Kent Goldings) with the appropriate amount of hops, depending on the year. The BU:GU ratio for 1939 was 2.41 and for 1943, 1.97. That's almost an 18% reduction. Now, it would seem that the IPA would, theoretically, be significantly less bitter because of such a sharp drop, but it's gravity is so low (by 1943, a mere 1031, down from 1939's 1037) that the hops still must have shined through, strongly.

So, the stouts seem about even, the pale ales are on the fence and with a final 1943 BU:GU of 1.97, and a gravity of 1031, the IPAs still had to be pretty bitter. This is all speculative of course, but I did put the tables to good use!

Thomas Barnes said...

@Ron. Sod Coventry! 50,000 hop pockets and the Brewers Hall! Those Nazi bastards! :)

@Craig. Interesting analysis. Just remember that beer gravities and hopping rates dropped gradually. Looking at Ron's tables, my guess is that the drop in gravity and hop character was most noticeable between 1940 and 1941.

BlogFront said...

Hi,

BlogFront.org is committed to uphold the quality standards of blogging. We strive to maintain and promote only the most credible blogs in their respective fields.

Spam blogs or "splogs" has been a problem for some time now and people are getting confused about which blog to trust.

We would like to thank you for maintaining such a reputable blog. We know that it takes time, effort and commitment to keep such a blog and as such, we have added your blog as one of the top Beer Blogs.

You can see your blog listed here: http://blogfront.org/beer/2

You can also claim your BlogFront Top Blogs badge at http://blogfront.org/badges/beer

Thank you for keeping your blog credible. Let's keep the blog revolution alive!

Maria Blanchard
BlogFront.org
Blog Revolucion